 |
|
| If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
|
|
| If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
|
| Datasheet File OCR Text: |
| (R) VN460SP SINGLE CHANNEL HIGH SIDE SMART SOLID STATE RELAY T YPE VN460SP V de ma g V CC -55V R DS(o n) 20 m IO UT 25 A V CC 36 V s s s s s s s OUTPUT CURRENT (CONTINUOUS): 25 A @ TC = 25 o C 5 V LOGIC LEVEL COMPATIBLE INPUT UNDER VOLTAGE SHUT-DOWN OVER VOLTAGE SHUT-DOWN THERMAL SHUT-DOWN OPEN DRAIN DIAGNOSTIC OUTPUT VERY LOW STAND-BY POWER DISSIPATION 10 1 Power SO-10 TM DESCRIPTION The VN460SP is a monolithic device made using SGS-THOMSON Vertical Intelligent Power Technology, intended for driving resistive or inductive loads with one side connected to ground. Built-in thermal shut-down protects the chip from over temperature and short circuit. BLOCK DIAGRAM The control input is 5V CMOS logic level compatible. The open drain diagnostic output indicates open circuit (no load) and overtemperature status. June 1998 1/9 VN460SP ABSOLUTE MAXIMUM RATING Symb ol VCC -V CC I OUT IR I IN I STAT -I GND V ESD P tot Tj T s tg Parameter Power Supply Voltage (continuous) Reverse Supply Voltage (continuous) Output Current (continuous) Reverse Output Current Input Current Status Pin Current Reverse Ground Current Electrostatic Discharge (1.5 k, 100 pF) Power Dissipation at T c 25 C Junction Operating Temperature Storage Temperature o Value 45 -0.3 Internally Limited -25 10 10 -200 2000 112 -40 to 150 -55 to 150 Unit V V A A mA mA mA V W o o C C CONNECTION DIAGRAM CURRENT AND VOLTAGE CONVENTIONS 2/9 VN460SP ELECTRICAL TRANSIENTS REQUIREMENTS ISO T/R 7637/1 Test Pu lse T EST LEVEL S I -25 V +25 V -25 V +25 V -4 V +26.5 II -50 V +50 V -50 V +50 V -5 V +46.5 III -75 V +75 V -100 V +75 V -6 V +66.5 IV -100 V +100 V -150 V +100 V -7 V +86.5 Delays an d Impedance 2 ms, 10 0.2 ms, 10 0.1 s, 50 0.1 s, 50 100 ms, 0.01 400 ms, 2 1 2 3a 3b 4 5 ISO T/R 7637/1 Test Pu lse 1 2 3a 3b 4 5 TEST L EVELS RESUL TS I C C C C C C II C C C C C E III C C C C C E IV C C C C C E (With a series resistor 1 K in input and status pins). CL ASS C E CONT ENT S All function of the device are performed as designed after exposure to disturbance. One or more functions of the device is not performed as designed after exposure and cannot be returned to proper operation without replacing the device. 3/9 VN460SP THERMAL DATA R t hj-ca se R thj-a () Thermal Resistance Junction-case Thermal Resistance Junction-ambient Max Max 1.1 50 o o C/W C/W () When mounted using minimum recommended pad size on FR-4 board. ELECTRICAL CHARACTERISTICS (VCC = 13 V; -40 oC < TJ < 125 oC unless otherwise specified) POWER Symb ol VCC V usd V ov R on IS Parameter Operating Supply Voltage Under Voltage Shut Down Overvoltage Shut Down On State Resistance Supply Current I OUT = 5 A I OUT = 5 A Off state On State T J = 25 C TCase = 25 C o o Test Cond ition s Min. 5.5 3 36 Typ . 13 4 39 Max. 36 5.5 45 20 36 Un it V V V m m A mA 15 1.4 30 3.3 LOGIC INPUT Symb ol VI L VI H V I(hyst.) I IN V ICL Parameter Input Low Level Voltage Input High Level Voltage (see note 1) Input Hysteresis Voltage Input Current Input Clamp Voltage VI N = 5 V I IN = 10 mA I IN = -10 mA Tc ase = 25 oC 5 6 -0.7 (*) (*) 3.5 0.2 0.85 1.5 100 7 Test Cond ition s Min. Typ . Max. 1.5 Un it V V V A V V (*) : The input voltage is internally clamped at 6 V about. It is possible to connect this pin to an higher voltage via an external resistor provided the input current does not exceed 10 mA. SWITCHING (VCC = 13 V) Symb ol t d(on) tr t d(of f) tf (di/dt) on (di/dt) off Parameter Turn-on Delay Time Of Output Current Rise Time O f O utput Current Test Cond ition s I OUT = 5 A Resistive Load Input Rise T ime < 0.1 s T j = 25 o C I OUT = 5 A Resistive Load Input Rise T ime < 0.1 s T j = 25 o C Min. 25 80 300 80 Typ . 90 300 750 200 0.02 0.02 Max. 250 650 1500 400 0.05 0.05 Un it s s s s A/s A/s Turn-off Delay Time O f I OUT = 5 A Resistive Load Output Current Input Rise T ime < 0.1 s T j = 25 o C Fall T ime Of Output Current Turn-on Current Slope Turn-off Current Slope I OUT = 5 A Resistive Load o Input Rise T ime < 0.1 s T j = 25 C I OUT = 5 A I OUT = 5 A 4/9 VN460SP ELECTRICAL CHARACTERISTICS (continued) PROTECTIONS AND DIAGNOSTICS Symb ol T TSD T TR T RSD (HYST) Parameter Thermal Shut-down Temperature Thermal Reset Temperature Thermal Hysteresis Output Voltage Authorizing Openload Detection Open Load Current Level Over Current Average Current in Short Circuit Status O utput Voltage Status Clamp Voltage Status Delay Status Delay Turn-off Output Clamp Voltage Test Cond ition s Min. 150 135 5 Typ . 170 Max. 190 Un it o C C C o 15 6.6 50 8 o VENOL 8VVCC 30V 5.2 V I OL I OV I AV V STAT V SCL t POL t POVL V DEMAG 8VVCC 30V R LOAD 10 m o o - 40 C 800 50 5.4 1500 mA A A 0.4 5.5 50 6 -0.7 300 7 950 10 V CC -45 VCC -50 V CC -55 V V V s s V () ISO definitions TPOL = Status delay in case of open load conditions TPOVL = Status delay in case of over load conditions 5/9 VN460SP FIGURE 1 SWITCHING PARAMETERS TEST CONDITIONS TRUTH TABLE Co nditi ons Normal Operation O ver-voltage Under-voltage T hermal shut-down O pen load H = high level, L= low level, X= unspecified INPUT L H X X H H OUT PUT L H L L L H STAT US H H H H L L 6/9 VN460SP FIGURE 2: Switching Waveforms 7/9 VN460SP PowerSO-10 MECHANICAL DATA DIM. MIN. A A1 B c D D1 E E1 E2 E3 E4 e F H h L q 0 o mm TYP. MAX. 3.65 0.10 0.60 0.55 9.60 7.60 9.50 7.40 7.60 6.35 6.10 1.27 1.25 13.80 0.50 1.20 1.70 8o 1.80 0.047 1.35 14.40 0.049 0.543 MIN. 0.132 0.000 0.016 0.013 0.370 0.291 0.366 0.283 0.283 0.240 0.232 3.35 0.00 0.40 0.35 9.40 7.40 9.30 7.20 7.20 6.10 5.90 inch TYP. MAX. 0.144 0.004 0.024 0.022 0.378 0.300 0.374 0.291 0.300 0.250 0.240 0.050 0.053 0.567 0.002 0.071 0.067 B 0.10 A B 10 = H = A F A1 = 6 = = = E = 1 5 e 0.25 M = E2 E3 E1 E4 = = A = SEATING PLANE DETAIL "A" Q B C h D = D1 = = = SEATING PLANE = A1 L DETAIL "A" 0068039-C 8/9 VN460SP Information furnished is believed to be accurate and reliable. However, STMicroelectronics assumes no responsibility for the consequences of use of such information nor for any infringement of patents or other rights of third parties which may result from its use. No license is granted by implication or otherwise under any patent or patent rights of STMicroelectronics. Specification mentioned in this publication are subject to change without notice. This publication supersedes and replaces all information previously supplied. STMicroelectronics products are not authorized for use as critical compone nts in life support devices or systems without express written approval of STMicroelectronics. The ST logo is a trademark of STMicroelectronics (c) 1998 STMicroelectronics - Printed in Italy - All Rights Reserved STMicroelectronics GROUP OF COMPANIES Australia - Brazil - Canada - China - France - Germany - Italy - Japan - Korea - Malaysia - Malta - Mexico - Morocco - The Netherlands Singapore - Spain - Sweden - Switzerland - Taiwan - Thailand - United Kingdom - U.S.A. . 9/9 |
Price & Availability of VN460
 |
|
|
|
|
All Rights Reserved © IC-ON-LINE 2003 - 2022 |
| [Add Bookmark] [Contact Us] [Link exchange] [Privacy policy] |
|
Mirror Sites : [www.datasheet.hk]
[www.maxim4u.com] [www.ic-on-line.cn]
[www.ic-on-line.com] [www.ic-on-line.net]
[www.alldatasheet.com.cn]
[www.gdcy.com]
[www.gdcy.net] |